Hyundai, Kia issue new U.S. recall of 168,000 vehicles for fire risks on Theta II engines

[snowman]

Hopefully this will be isolated to the 2011-2014 models. I believe the Stinger 2.0L also uses the Theta II.

Hyundai Motor Co and affiliate Kia Motors Corp said on Wednesday they will recall about 168,000 U.S. vehicles at risk of fuel leaks, after recalling them in 2017 for engine fire risks, and will offer software upgrades for 3.7 million vehicles.

A high-pressure fuel pipe may have been damaged or improperly installed as part of an engine replacement during the prior recall, and that installation could increase the risk of fire, the companies said.

The Korean automakers said the software update aims to protect the vehicles from internal damage, and they will also offer new extended warranties for engine issues. The "knock sensor" software detects vibrations indicating the onset of excessive wear on the connecting rod bearing.

Kia said that 20 percent of the vehicles involved have already received the update.

The new recall covers 68,000 various Kia Optima, Sorento and Sportage vehicles from the 2011 through 2014 model years, while Hyundai said it affects 100,000 2011-2014 Hyundai Sonata and 2013-2014 Hyundai Santa Fe Sport vehicles.

Kia said six fires are linked to the new recall but no reports of injuries, while Hyundai said it had no reports of fires linked to the new recall.

In May 2017, the National Highway Traffic Safety Administration (NHTSA) opened a formal investigation into the recalls of nearly 1.7 million Hyundai and Kia vehicles over engine defects.

In November 2018, Reuters reported that federal prosecutors had launched a criminal investigation into Korean auto affiliates Hyundai and Kia https://reut.rs/2VVMwYm to determine if vehicle recalls linked to engine defects were conducted properly, citing a person with knowledge of the matter and documents. The companies declined to comment.

A South Korean whistleblower in 2016 reported concerns to NHTSA, which has been probing the timeliness of three U.S. recalls and whether they covered enough vehicles.

In 2015, Hyundai recalled 470,000 U.S. Sonata sedans, saying engine failure would result in a vehicle stall, increasing the risk of a crash. At the time, Kia did not recall its vehicles, which share the same “Theta II” engines.

In March 2017, Hyundai expanded its original U.S. recall to 572,000 Sonata and Santa Fe Sport vehicles with “Theta II” engines, citing the same issue involving manufacturing debris.

On the same day, Kia also recalled 618,000 Optima, Sorento and Sportage vehicles, all of which use the same engine.

The recall, which was also conducted in Canada and South Korea, cost the automakers an estimated 360 billion won ($319.3 million). The nonprofit Center for Auto Safety in October called for the immediate recall of another 2.9 million Hyundai and Kia vehicles over engine fire risks.

 

[MurlinatoR]

This recall is VERY isolated.

It's not a factory defect. This is a service related recall. These cars that are under recall are vehicles that previously had an engine replaced by the service department. I expect very few of these vehicles to have an actual problem.